0BS907554D Haldex Control Unit Gen 4 | Refurbished OEM
Refurbished Haldex Control Unit 0BS907554D
Part Number: 0BS907554D
OEM original rear differential / Gen 4 Haldex AWD control module for Volkswagen Group vehicles
System Type
Haldex AWD 4th Generation
Condition
Refurbished Fully Functional
Manufacturer
Continental
Supplier Reference
HAP542 / 5WP33527-01
Software / Hardware
SW 4017 / HW H43
Warranty
12 Months
Tested & Verified Working Unit
Each module is professionally refurbished, fully bench tested and prepared as a reliable OEM replacement for a faulty original Haldex controller. The unit is intended to restore stable rear differential control, proper AWD engagement and correct communication with drivetrain electronics.
Always Verify Your Part Number
Before placing an order, check the OEM number printed directly on your existing Haldex control unit and confirm it matches the references listed above. If you are unsure about compatibility, contact us and we will help verify fitment.
Technical Specifications
System Type:
Haldex AWD 4th Generation
Component:
Rear Differential Control Unit
Application:
Volkswagen Group AWD / 4x4 vehicles with Gen 4 Haldex
Manufacturer:
Continental
Supplier Ref:
HAP542 / 5WP33527-01
Software Version:
4017
Hardware Version:
H43
Part Condition:
Refurbished Tested & Verified Working
Product Description
This is a genuine refurbished OEM Haldex control unit with part number 0BS907554D. It is a key electronic component of the fourth-generation Haldex all-wheel-drive system and is responsible for activating and regulating the rear differential clutch pack in response to traction demands and driving conditions.
What This Control Module Does
Controls rear differential clutch engagement in the 4th gen Haldex system
Helps restore correct AWD performance when the original module has failed
Communicates with ABS, ESP and drivetrain electronics
Manages the N373 Haldex control valve for clutch pressure regulation
Supports stable rear axle engagement in changing traction conditions
Direct OEM Replacement
This module is intended as an OEM replacement for the original control unit. Coding or adaptation may be required after installation depending on the vehicle configuration, and online support is available if needed.
Vehicle Compatibility
The 0BS907554D is compatible with selected Volkswagen Group vehicles equipped with Gen 4 Haldex AWD. Always verify the exact part number on your existing module before ordering.
Škoda
Škoda Octavia
Škoda Superb
Volkswagen
Volkswagen Passat
Volkswagen Passat CC
Volkswagen Tiguan
Volkswagen Sharan
Volkswagen Caddy
Audi
Audi Q3
Audi TT
SEAT
SEAT Alhambra
Not Sure About Compatibility?
If you are unsure whether this control unit fits your vehicle, send us your VIN number or the OEM number from your existing module. We will help confirm compatibility before you order.
Common Symptoms of a Faulty Module
A defective Haldex control unit commonly causes the following issues:
Loss of AWD / 4x4 function or no rear axle engagement
00003 Control module faulty
00448 Haldex clutch pump (V181)
02248 Clutch control valve (N373)
01324 All Wheel Drive Control Module (J492) no communication / intermittent
16347 Control module EEPROM error
65535 Internal control module memory error
ESP / ABS warning lights on the dashboard
No communication fault during diagnostics
Diagnostic Tip
If this module is being replaced, it is recommended to inspect the Haldex control valve N373 and related system components. A proper VAG-compatible diagnostic scan should be carried out before and after installation.
Installation
Installation Steps
Locate the Haldex control unit mounted on the rear differential assembly
Disconnect the electrical connector and remove the old module
Install the replacement unit and secure all mounting points properly
Reconnect all electrical connectors and verify a secure fit
Clear stored fault codes with suitable diagnostic equipment
Code or adapt the module if required by the vehicle
Perform a test drive and confirm correct AWD engagement
Online Technical Support Included
If the control unit requires coding assistance after installation, our technical team is available to help. Reach us using the contact button below or at [email protected]
Why Haldex Control Units Fail
1. Water Ingress & Sealing Failure
Moisture and damaged sealing can affect the control unit housing and internal electronics, leading to corrosion, unstable communication and complete AWD malfunction.
2. Valve or Pump Related Faults
Failure of the Haldex pump or the N373 clutch control valve can overload the system and trigger repeated module-related diagnostic errors.
3. Internal Electronic Failure
EEPROM faults, internal memory errors and circuit-board wear can cause intermittent operation, no communication faults or complete loss of rear differential control.
4. Wiring or Power Supply Problems
Damaged wiring, poor terminal contact or unstable power supply can interrupt module operation and create misleading communication or actuator fault codes.
Warranty
12-Month Warranty: This refurbished Haldex control unit has been tested for correct operation and is supplied with a 12-month warranty under normal operating conditions.
Warranty Coverage Includes:
Internal control unit malfunction
Communication failures caused by the module itself
Faults related to internal memory or controller operation
Warranty Exclusions:
Incorrect installation or incompatible vehicle fitment
External wiring, pump or valve faults
Physical damage, water damage after installation or mishandling
Questions or Need Help?
Our technical team is ready to assist with compatibility checks, installation guidance and coding support.
Great selection of parts. Reasonable pricing. Fast delivery and super service/support. My new Haldex ECU worked like a charm, once the car had recognised it (took a couple of restarts of the car and fault code clearing with OBDeleven). Highly recommend!
Fantastic company, Jakub who is very helpfull and swift to reply. Helped me fix my haldex gen 5 myself, would really recommend anyone to work with or buy from this great company! Thanks again for your help Jakub
